jenisjenis stone crusher buatan eropa

jenisjenis stone crusher buatan eropa

RECOVERY OF COPPER FROM

RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION AND LEACHING Kiraz, Emirhan M.S., Department of Mining Engineering Supervisor: Prof. Dr. Mustafa Ümit Atalay December 2014, 65 pages The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) leaching.

Get Price

Native Copper Flotation - Froth Flotation (Sulphide ...

Benedict (1955) discusses development of flotation practice for native copper ores. Conglomerate ores - Comment is made that Minerals Separation Co. was unable to get response. Test work at CH involved testing various distillation by-products identified an active collector (active ingredient was pyridine).

Get Price

Agitated Copper Leaching

Apr 14, 2016  Copper Agitated Leaching and cementation process of copper problem: The treatment of copper ores, both oxides and sulfides by means of flotation, hydrometallurgy or other processes has been well established for many years. Flotation has been applied generally to the treatment of sulfide ores, both in small and large scale operations.

Get Price

Development of copper recovery

Jun 15, 2018  A new flotation tailings treatment process was developed for efficient Cu recovery. • An efficient Cu dissolution was achieved in an H 2 O media in presence of pyrite.. The dissolution mechanism of CuFeS 2 has been confirmed to be a multistage reaction.. Fe was always co-dissolved with Cu following a linear relation of C Fe = 38.393 × C Cu.. Over 91% Cu was extracted from pregnant leach ...

Get Price

Copper Flotation - 911 Metallurgist

May 16, 2016  A Copper Flotation Flowsheet. Because the copper in this type of ore usually assays only plus or minus 1% copper, the porphyry copper operations must be relatively large in order to be commercial. The flowsheet in this study illustrates a typical 3,000 ton per day operation. In general most operations of this type have two or more parallel ...

Get Price

Copper Sulfide Flotation - 911 Metallurgist

Apr 13, 2016  Flowsheet for treatment of Copper Sulfide ores rich inminerals such as chalcopyrite with gold and silver as well as arsenopyrite. The above flowsheet is designed for the treatment by flotation of copper as chalcopyrite with gold and silver values. The ore, ranging from 60-65% silica, with pyrite, arsenopyrite, and calcite with 3 to 4% copper.

Get Price

Recovery of Copper from Ammoniacal Leachates by Ion Flotation

Apr 27, 2021  Up to10%cash back  Copper and zinc extraction by ammoniacal leaching from microwave-roasted Cu-Zn-Pb sulfidic tailings followed by recovery of copper and zinc by ion flotation and precipitation. Introduction Tailings are mixtures of fine-grained unwanted fractions after mineral beneficiation of ores at a mining site that are considered as a waste [ 1 , 2 ].

Get Price

Recovery of PGMs from an oxide ore by flotation and leaching

by flotation and leaching Msc Research Thesis Prepared by: Relebohile Sefako Student number: 1420412 ... sulphuric acid was only efficient for copper and nickel while poor iron recoveries were achieved. ii . iii ... concentration on base metal leach recovery at 105 oC..... 66 Figure 35: Geometric ...

Get Price

LEACHING OF LOW-GRADE COPPER ORES: A CASE STUDY

leaching was investigated with respect to acid concentration and solid to liquid ratio. The copper concentration in the leach solution ranged from 0.80 to 1.75 g dm-3. The total Cu recovery rate ranged from 30 to 56 %, whereas the recovery rate of copper oxide minerals ranged from 67 to 100 %. Furthermore, with increasing the amount of liquid

Get Price

Investigation of the possibility of copper recovery from ...

The aim was to determine the leaching kinetics of copper and iron as affected by various factors such as: the pH value of the leach solution, stirring speed, pulp density, particle size, concentration of ferric ions, temperature and time for leaching. The average copper and iron recovery obtained was from 60% to 70% and from 2% to 3%, respectively.

Get Price

Recovery of Copper from Ammoniacal Leachates by Ion Flotation

Apr 27, 2021  Copper and zinc extraction by ammoniacal leaching from microwave-roasted Cu-Zn-Pb sulfidic tailings followed by recovery of copper and zinc by ion flotation and precipitation. Introduction Tailings are mixtures of fine-grained unwanted fractions after mineral beneficiation of ores at a mining site that are considered as a waste [ 1 , 2 ].

Get Price

Recovery of Copper from Flotation Tailings by Leaching ...

The leaching solution obtained under the optimal copper leaching conditions, was used to be proceeded for extracting and electrodepositing test. The best leaching conditions are stirring speed of 30 m/min, H2SO4 concentration of 150 Kg/t ore, leaching time of 30 minutes. ... Recovery of Copper from Flotation Tailings by Leaching. Article Preview.

Get Price

RECOVERY OF COPPER FROM COPPER SLAG AND COPPER

Recovery of copper from copper slag and copper slag flotation tailings 75by oxidative leaching Table 1. Chemical compositions of the copper smelter slag and the slag flotation tailings Constituent Content (wt.%) Copper Slag Slag Flotation Tailings Cu – total 0.97 0.59 Cu – oxides 0.15 0.06 Cu – sulphides 0.82 0.53 SiO 2 33.75 34.62 Al 2 O

Get Price

Techniques of copper recovery from Mexican copper oxide ...

Mexican copper ore is a mixed ore containing mainly copper oxide and some copper sulfide that responds well to flotation. The joint techniques of flotation and leaching were studied. The results indicate that an ore containing 19.01% copper could be obtained at a recovery ratio of 35.02% by using sodium sulfide and butyl xanthate flotation.

Get Price

Recovery of PGMs from an oxide ore by flotation and leaching

by flotation and leaching Msc Research Thesis Prepared by: Relebohile Sefako Student number: 1420412 ... sulphuric acid was only efficient for copper and nickel while poor iron recoveries were achieved. ii . iii ... concentration on base metal leach recovery at 105 oC..... 66 Figure 35: Geometric ...

Get Price

Development of a Combined Flotation and High Pressure ...

efficiency of copper and nickel from the flotation with high preconcentrate s-sure oxidative leaching (HPOL). A comparison was made between the leaching efficiencies of copper and nickel from flotation concentrates and mine tailing. Keywords Mine Tailing, Flotation, High Pressure Leaching, Copper, Nickel 1. Introduction

Get Price

Gold Recovery 101 From Sepro's Gold Recovery Experts

Both sulfide and oxide copper minerals can be consumers of cyanide. In the case of native copper or oxide copper minerals, sulfuric acid leaching can remove the copper prior to cyanidation. Sulfide minerals that consume cyanide are typically preconcentrated by flotation before being oxidized using roasting, pressure oxidation or bio-oxidation.

Get Price

Leaching and recovery of platinum group metals from UG

Existing processes for the recovery of platinum group metals (PGM) from UG-2 ores place stringent requirements with regard to chromite content (about 2.8 per cent) upon feed material to the plant. The conventional process sequence involves: smelting of a flotation concentrate to remove gangue material and to produce an iron-nickel-copper-PGM matte

Get Price

Review, Evolution and Optimization of the Kansanshi Mixed ...

Native copper Cu 2 (CO 3) 2.Cu(OH) 2 Cu 2 O CuO (Cu,Al) 2 H 2 Si 2 O 5 (OH) 4.nH 2 O Cu The traditional method applied for the flotation of copper oxide or mixed ores is sulphidisation, which was first developed with industrial success on Pb–Zn oxide ores in Australia (Crozier, 1991). The method involves multistage addition of sodium sulphide ...

Get Price

v116n6a11 Review, evolution, and optimization of the ...

in 2014. Of note was the development of a recovery model, based on the strong correlation between the total copper and acid-soluble copper ratio, as a tool for monitoring plant performance. 4 2/), copper, flotation, optimization, mixed ore, sulphidization, modelling. * First Quantum Minerals Ltd, Kansanshi Mine, Solwezi, Zambia.

Get Price

[PDF] Recovery of copper from the copper slag and copper ...

Copper extraction from the slag was typically found to be twice as high as that from the slag flotation tailings. Hydrogen peroxide was determined to be the best lixiviant. Thus, copper and iron extractions were 63.4% and 48.6%, respectively, when leaching the slag with 3 M H2O2, after 120 minutes of reaction at room temperature.

Get Price

Gold and copper recovery from flotation concentrates of ...

Jan 24, 2018  The authors present the data on the substance analysis of gold–copper–arsenic flotation concentrate. Gold and copper recovery by autoclave leaching of the concentrate has been studied. It is found that maximum gold and copper recovery under optimum conditions reaches 96 and 92%, respectively. The profitability of the proposed process flowsheet is proved by the technical-and

Get Price

Acid leaching of oxide–sulfide copper ore prior the ...

453 Acid leaching of oxide–sulfide copper ore prior the flotation – A way for an increased metal recovery Miroslav D. Sokić1, Vladan D. Milošević1, Velizar D. Stanković2, Vladislav Lj.Matković1, Branislav R. Marković1 1Institute for Technology of Nuclear and Other Mineral Raw Materials, Belgrade, Serbia 2University of Belgrade, Technical Faculty, Bor, Serbia

Get Price

Investigation of the possibility of copper recovery from ...

The aim was to determine the leaching kinetics of copper and iron as affected by various factors such as: the pH value of the leach solution, stirring speed, pulp density, particle size, concentration of ferric ions, temperature and time for leaching. The average copper and iron recovery obtained was from 60% to 70% and from 2% to 3%, respectively.

Get Price

Recovery of Copper from Flotation Tailings by Leaching ...

The leaching solution obtained under the optimal copper leaching conditions, was used to be proceeded for extracting and electrodepositing test. The best leaching conditions are stirring speed of 30 m/min, H2SO4 concentration of 150 Kg/t ore, leaching time of 30 minutes. ... Recovery of Copper from Flotation Tailings by Leaching. Article Preview.

Get Price

Recovery of PGMs from an oxide ore by flotation and leaching

by flotation and leaching Msc Research Thesis Prepared by: Relebohile Sefako Student number: 1420412 ... sulphuric acid was only efficient for copper and nickel while poor iron recoveries were achieved. ii . iii ... concentration on base metal leach recovery at 105 oC..... 66 Figure 35: Geometric ...

Get Price

Treatment of copper-rich gold ore by cyanide leaching ...

Native copper Cu 90 100.0 Cuprite Cu2O 85.5 100.0 ... Despite its potential benefits for cyanide leaching, downstream gold recovery and effluent treatment, ... and the flotation concentrate produced from the ore. Accordingly, copper was identified to be present as

Get Price

LEACHING OF LOW-GRADE COPPER ORES: A CASE STUDY

leaching was investigated with respect to acid concentration and solid to liquid ratio. The copper concentration in the leach solution ranged from 0.80 to 1.75 g dm-3. The total Cu recovery rate ranged from 30 to 56 %, whereas the recovery rate of copper oxide minerals ranged from 67 to 100 %. Furthermore, with increasing the amount of liquid

Get Price

Recovery of Copper by Solution Mining Methods

Recovery of Copper by Solution Mining Methods 1 Recovery of Copper by Solution Mining Methods David F. Briggs, Economic Geologist 3514 West Blacksill Drive Tucson, Arizona 85741 Phone - 520-744-4195 Cell - 520-784-3954 Introduction Solution mining is a mining practice that employs solutions (i.e. water or dilute acid) to recover a desired commodity

Get Price

Review, Evolution and Optimization of the Kansanshi Mixed ...

Native copper Cu 2 (CO 3) 2.Cu(OH) 2 Cu 2 O CuO (Cu,Al) 2 H 2 Si 2 O 5 (OH) 4.nH 2 O Cu The traditional method applied for the flotation of copper oxide or mixed ores is sulphidisation, which was first developed with industrial success on Pb–Zn oxide ores in Australia (Crozier, 1991). The method involves multistage addition of sodium sulphide ...

Get Price

Extractive Metallurgy of Copper ScienceDirect

The flotation is made selective by using reagents, which make the Cu-sulfide minerals water-repellant (hydrophobic) while leaving the other minerals wetted (hydrophilic). Typical Cu sulfide recoveries to concentrate are 85–90%. Typical concentrate grades are 30% Cu (higher with chalcocite, bornite, and native copper mineralization).

Get Price

The selective leaching of copper from a gold–copper ...

gold leaching either using the same process at elevated temperature (40–60 °C), as patented by the authors, or using a cyanidation process. Copper selective leaching will reduce the gold losses due to a cementa-tion mechanism of gold in the presence of metallic copper as all of the metallic copper will dissolve in the pre-leaching stage.

Get Price

v116n6a11 Review, evolution, and optimization of the ...

in 2014. Of note was the development of a recovery model, based on the strong correlation between the total copper and acid-soluble copper ratio, as a tool for monitoring plant performance. 4 2/), copper, flotation, optimization, mixed ore, sulphidization, modelling. * First Quantum Minerals Ltd, Kansanshi Mine, Solwezi, Zambia.

Get Price

Acid leaching of oxide–sulfide copper ore prior the ...

453 Acid leaching of oxide–sulfide copper ore prior the flotation – A way for an increased metal recovery Miroslav D. Sokić1, Vladan D. Milošević1, Velizar D. Stanković2, Vladislav Lj.Matković1, Branislav R. Marković1 1Institute for Technology of Nuclear and Other Mineral Raw Materials, Belgrade, Serbia 2University of Belgrade, Technical Faculty, Bor, Serbia

Get Price

Copper Recovery from Silicate-Containing Low-Grade

the recovery of copper from low-grade copper ore by flotation followed by the leaching process in which a high-pressure leaching was selected as a major approach. In addition, there are few refer-ences related to the copper leaching from the low-grade copper resources using high-pressure oxi-dative leaching as an alternative approach for

Get Price

Enhanced methods for nickel recovery from low-grade ores ...

Copper-selective solvents can be chosen, and many steps are followed to get nickel and copper powder from the bleed. The following block flow diagram was shown in a paper by A. Agrawal et al. in 2012, demonstrating the steps of SX for nickel and copper recovery, Figure 5.

Get Price

Copper Commodities - engenium.au

Copper occurs as either native copper or in minerals such as copper sulphides (chalcopyrite, ... flotation, oxidative pressure leaching, bacterial leaching, ferric leaching, ammonia leaching or a combination ... • Recovery from leach solutions by EW, SX, IX, precipitation, cementation or crystallisation. ...

Get Price

Development of copper recovery process from flotation ...

Jun 15, 2018  Therefore, this research aims to develop a copper recovery process from flotation tailings using high‒pressure leaching (HPL) followed by solvent extraction. Over 94.4% copper was dissolved from the sample (CuFeS2 as main copper mineral) by HPL in a H2O media in the presence of pyrite, whereas the iron was co‒dissolved with copper according ...

Get Price

Investigation of the possibility of copper recovery from ...

The aim was to determine the leaching kinetics of copper and iron as affected by various factors such as: the pH value of the leach solution, stirring speed, pulp density, particle size, concentration of ferric ions, temperature and time for leaching. The average copper and iron recovery obtained was from 60% to 70% and from 2% to 3%, respectively.

Get Price

Cobalt and copper recovery from the ancient flotation ...

The ancient flotation tailings from Lefke, Cyprus, have a potential for non-ferrous metals such as cobalt and copper from more than 9.5 million tons of reserves containing 0.38% Cu, 0.032% Co, and 22.6% Fe. Recovery of cobalt and copper from these tailings can provide great benefits from economic and environmental perspectives.

Get Price

Recovery of Copper from Flotation Tailings by Leaching ...

The leaching solution obtained under the optimal copper leaching conditions, was used to be proceeded for extracting and electrodepositing test. The best leaching conditions are stirring speed of 30 m/min, H2SO4 concentration of 150 Kg/t ore, leaching time of 30 minutes. ... Recovery of Copper from Flotation Tailings by Leaching. Article Preview.

Get Price

RECOVERY OF COPPER FROM SMELTING SLAG BY

Copper Smelter, Serbia, is currently processed by flotation at the nearby Bor Copper Concentrator. The copper recovery was rather low (about 40%) mainly due to the presence of oxide copper and insufficient mineral liberation. In our previous work, we investigated the technical feasibility of increasing copper recovery by leaching and flotation ...

Get Price

Innovations in Copper Mineral Processing Technology

Leaching Metal Recovery SX/EW SX/Crystallisation Precipitation Cementation Tailings ROM ore Products-Cathode-Sulphate ... Native Copper. Examples of GAC Rock Removal ... Liberated Gangue recovered by "Entrainment" or "True" Flotation Plant Recovery. Copper Recovery – Case Study 10 15 20 25 30 35 40 0 10 20 30 40 50 60 70 80 90 100

Get Price

Review, Evolution and Optimization of the Kansanshi Mixed ...

Native copper Cu 2 (CO 3) 2.Cu(OH) 2 Cu 2 O CuO (Cu,Al) 2 H 2 Si 2 O 5 (OH) 4.nH 2 O Cu The traditional method applied for the flotation of copper oxide or mixed ores is sulphidisation, which was first developed with industrial success on Pb–Zn oxide ores in Australia (Crozier, 1991). The method involves multistage addition of sodium sulphide ...

Get Price

Gold and copper recovery from flotation concentrates of ...

Jan 24, 2018  The authors present the data on the substance analysis of gold–copper–arsenic flotation concentrate. Gold and copper recovery by autoclave leaching of the concentrate has been studied. It is found that maximum gold and copper recovery under optimum conditions reaches 96 and 92%, respectively. The profitability of the proposed process flowsheet is proved by the technical-and

Get Price

Recovery of Copper from Reverberatory Copper Slag and ...

Copper Cobalt Africa, incorporating the 8th Southern African Base Metals Conference Livingstone, Zambia, 6–8 July 2015 Southern African Institute of Mining and Metallurgy 247 Recovery of Copper from Reverberatory Copper Slag and Production of a Leach Residue used as a Portland Cement Additive T. A. Muhlare and D. R. Groot

Get Price

RECOVERY OF COBALT AND NICKEL BY ATMOSPHERIC

cobalt and copper recovery. It was found, that both the Ni and Co leaching rate and leaching recovery depend on copper leaching recovery value. Cobalt and nickel start to leach very rapidly when about 90 – 95% of copper is leached out. This suggests, that Co and Ni sulfides are disseminated in the matrix of copper minerals and leaching

Get Price

Copper Recovery from Silicate-Containing Low-Grade

the recovery of copper from low-grade copper ore by flotation followed by the leaching process in which a high-pressure leaching was selected as a major approach. In addition, there are few refer-ences related to the copper leaching from the low-grade copper resources using high-pressure oxi-dative leaching as an alternative approach for

Get Price

Experimental investigation and adaptive neural fuzzy ...

Jul 23, 2019  The potential of copper recovery from flotation tailings was experimentally investigated using a laboratory-mixing tank. The experiments were performed with solid weight percentages of 30wt%, 35wt%, 40wt% and 45wt% in water. The measurements revealed that adding sulfuric acid all at once to the tank rapidly increased the efficiency of the leaching process, which was attributed to the rapid ...

Get Price

THIOSULFATE LEACHING OF SILVER FROM A SOLID RESIDUE

604 K. Wejman-Gibas, T. Chmielewski, K. Borowski, K. Gibas, M. Jeziorek, J. Wodka where: R % metal leaching recovery, % C metal concentration in the solution, g/dm 3 (mg/dm ) V leaching solution volume, dm3 M mass of the concentrate, g Α metal content in the concentrate, % (g/Mg). The subject of this study was a solid residue after pressure leaching of the

Get Price

Treatment of copper-rich gold ore by cyanide leaching ...

Native copper Cu 90 100.0 Cuprite Cu2O 85.5 100.0 ... Despite its potential benefits for cyanide leaching, downstream gold recovery and effluent treatment, ... and the flotation concentrate produced from the ore. Accordingly, copper was identified to be present as

Get Price

Copyright © 2021.Company name All rights reserved. Sitemap